Thursday, November 21, 2013

How replace auto door glass on a 1997 Pontiac Grand Am

The right rear passenger door glass on a 1997 Pontiac Grand Am was shattered with a beer can  by a vandal late one recent night. I repaired it with glass from an auto scrap yard for $25.

Disassembly
1) Remove two Philips screws in the door pull.

Removing the two door pull screws

2) Remove the  hand crank. Separate with a prybar to create a gap so that the a metal retaining clip can be removed. Use a hooked tool to pull the clip out. I used a dental pick.
3) Pry off the red door reflector and remove the Philips screw beneath it.
4) Unsnap the four panel fasteners at the bottom of the door. These are wire on this car.
5) Carefully unsnap the plastic molded piece that covers the handle and the lock lever and pull it to the left.
Turn it so that it slips over the door handle.

Slip the molded piece over the door handle
6) From the outside of the door lift up the top of the big inner panel, by prying it upward with a screwdriver.
There are three downward pointing plastic holders on the panel,  that mount in rectangular cut-outs in the door.
7) Remove the entire inner panel by pulling upward.

Here is a view of the inner door panel when removed

8) Remove the metal door-pull bracket (4 Philips screws)
9) Remove the clear plastic adhesive-backed sheet.
10) Remove the horizontal inner lower window seal.
11) Pull the inner side window seal outward and remove it from the door jamb up to where it heads back down.

Prying out the window guide seal

12) Remove two Philips screws on the inside pillar of the window jamb. Remove the plastic trim piece. Be careful, it’s plastic.
13) Loosen the plastic glass holders ( they were riveted to the window glass) from the under bar with a 10mm socket and ratchet.

Go to scrapyard and remove glass from a junked car. I paid $25 for the glass.

Reassembly
1) Feed the replacement glass through the upper door, seating it in the outer rubber guide. Go to the other side and line the plastic pieces on the bottom with under rail hard ware.  Use the crank if needed to position it.  Tighten with 10mm socket.
2) Install the inner trim piece with the two Philips screws.
3) Re-seat the rubber upper and side window seal in its slot.
4) Test the window operation by temporarily reinserting the crank. If Ok continue.
5) Re-install the plastic sheeting .You may need to use a bit of silicone to hold it in place.
6) Re-install the door pull bracket with the four Philips screws.
7) Re-install the big inner door cover. Push it in place from the top, seating the three upper clips. Then re-seat the remaining panel fasteners.
8) Install the screw behind the door reflector.
9) Install the reflector.
10) Install the window crank.  Put the clip partially in place first, then seat the crank and lock the clip in place with a dental pick or right angle tool.
11) Install the two door pull screws.

Here is a video of this job:



43 comments:

  1. What a commendable work you have done, with simplest of language. I can’t resist myself to leave a comment and trust me it’s hard to impress me..

    ReplyDelete
    Replies
    1. Thanks for taking the time to comment. I really appreciate it.

      Delete
  2. We offer a 24/7 mobile car unlocking service . Our auto locksmith service is designed to help you whenever you have accidentally locked your key in your car or trunk. Our highly trained and experienced car locksmiths can unlock you car door or trunk without causing any damage.

    Our technicians constantly receive training and they utilize the newest technology, tools and state- of- the -art locksmith equipment to provide you with the best car lockout solutions. flatratelocknkey-denver.com/ We take care too, to keep your car door and auto lock safe while we work on the problem. Our customers are valuable and we ensure that the job is completed to 100% customers’ satisfaction.

    Our roadside service professionals are highly competent individuals with extensive knowledgeable about most vehicle types and are therefore capable of making replacement keys for any model.

    ReplyDelete
  3. I am happy to find this post very useful for me, as it contains lot of information.
    FastFix Services Locksmith

    ReplyDelete
  4. Unlike traditional locksmiths, an auto locksmith relies on special decoding machinery to do their work. This is because newer cars manufactured since the mid-1990s have keying systems that work differently from their older cousins.автоключар

    ReplyDelete
  5. Then, you may not be given a quote for the locksmith service or given a false quote. When the locksmith arrives, he may want more money and you feel pressured and stuck.duplicate key maker

    ReplyDelete
  6. Things that you have to remember with the end goal for you to not experience challenges with door key locks are in the first place, make sure that the pivots are fixed. key duplication near me

    ReplyDelete
  7. An Internet look for glass repair raises numerous sites devoted to repairing glass things, for example, auto windshields, glass entryways, and windows. Glass Repairing

    ReplyDelete
  8. Hiiiiiiiiiiiiiii...... like this theme extremely much......
    Car key Replacement

    ReplyDelete
  9. This is the right blog for everyone who is desires to learn about this topic. You understand a whole lot its virtually challenging to argue on hand (not that I really would want…HaHa). You definitely put a whole new spin on a topic thats been discussing for some time. Great stuff, just fantastic! tinted windows london

    ReplyDelete
  10. you write very well this article, i got good information after read your effective writing style. i hope you will continue this good work. Porsche 718 Boxter

    ReplyDelete
  11. Among one of the finest pieces on the internet, freshening in its specificity.
    Locksmith Midwood NY

    ReplyDelete
  12. superb way of explaining, and great blog to get wonderful information.
    locksmith arlington tx

    ReplyDelete
  13. Good website! I truly love how it is easy on my eyes it is. I am wondering how I might be notified whenever a new post has been made. I have subscribed to your RSS which may do the trick? Have a great day! car hail damage repair

    ReplyDelete
  14. I want to say thank to you people for this great and helpful info. Thanks!!!
    plano locksmith

    ReplyDelete
  15. Thanks so much for this information.  I have to let you know I concur on several of the points you make here and others may require some further review. but I can see your viewpoint. Click Here

    ReplyDelete
  16. Cheap locksmith services suffer from the problem of plenty, ironically. Cheap locksmiths, preferably called affordable locksmiths, as the name suggests, are inexpensive.vehicle lockout service bend oregon

    ReplyDelete
  17. Have you ever been locked out of your car or home? Either you can't find your car keys or you locked yourself out of your home. unlock car

    ReplyDelete
  18. Hey, I'm a long time fan and reader of your blog, first time commenter. Just wanted to say this post really hit home with the stuff I've been looking into. Thanks man
    Low Rate Locksmith Sacramento ca

    ReplyDelete
  19. You completed a few fine points there. I did a search on the subject and found nearly all persons will go along with with your blog. french and sliding doors

    ReplyDelete
  20. Different kinds of door locks are used for different kinds of abode. Hotels, nowadays, prefer using cards. The guest who would check-in is given identification-card to serve as their keys.Links Locksmith Services Jacksonville FL 23335

    ReplyDelete
  21. A door can require fix for any number of reasons. Most ordinarily in a more seasoned home a door can wind up turning into an issue in light of the fact that the house settles.sistemi scorrevoli per porte

    ReplyDelete
  22. I discovered your this post while hunting down data about blog-related research ... It's a decent post .. continue posting and refreshing data.
    lisa olson pregnancy miracle bad reviews

    ReplyDelete
  23. Hello – extraordinary blog, simply checking out a few web journals, appears a truly pleasant stage you are utilizing.
    lisa olson pregnancy miracle bad reviews

    ReplyDelete
  24. This comment has been removed by the author.

    ReplyDelete
  25. Different kinds of door locks are used for different kinds of abode. Hotels, nowadays, prefer using cards. The guest who would check-in is given identification-card to serve as their keys. This type of keys to lock doors is, most of the time, programmed to be used only during the stay of that particular guest.Fisher & Paykel, Gaggenau, Thermador, SubZero, Viking Freezer Repair in Los Angeles

    ReplyDelete
  26. These electronic locks would help them maintain all the important security purposes as they are prepared to do this. If anyone forces an unlock, an alarm will sound to make the owner concerned. This is such reliable option for our safety.Washer Repair Near Me

    ReplyDelete
  27. The locks are programmed to recognize the fingerprints of the authorized person. It scans the fingerprints of the person and unlocks the door. Some of these locks are programmed to recognize and accept the fingerprints of different people living in the same premises.front door locks

    ReplyDelete
  28. Pick your car locksmith astutely. It's a choice that will help keep your vehicle fit as a fiddle and protect you. Emergency Locksmith Gold Coast

    ReplyDelete
  29. Opening your vehicle entryways or trunk in a crisis without harming the lock. visit website

    ReplyDelete
  30. One must take the specific tests regulated by these focuses to win a specific confirmation, for example, Enrolled Locksmith, Guaranteed Car Locksmith, Ensured Ace Safe Tech, Affirmed Enlisted Locksmith, Confirmed Proficient Locksmith, Confirmed Ace Locksmith and Confirmed Proficient Safe Tech.key duplication near me

    ReplyDelete
  31. Unfortunate turn of events. Since you have to utilize your vehicle to drive back home, you recently understood that in your rush, you neglected to take your vehicle keys with you. Schlüsseldienst in Aachen

    ReplyDelete
  32. Modest locksmith administrations experience locksmith Toronto the ill effects of the issue of bounty, unexpectedly.

    ReplyDelete
  33. The electronically controlled locks that accompany such a framework can make your home extremely protected.residential locksmith

    ReplyDelete
  34. "Since I'm worn out on managing keys everytime I get back home. A fraction of the time I drop them when I'm attempting to discover the lock, and I can't see the lock to place the key in when I do have them in my grasp!" he advised me. slotenservice-rotterdam010

    ReplyDelete
  35. You have provided valuable data for us. It is great and informative for everyone. Keep posting always. I am very thankful to you. entry doors Palatine

    ReplyDelete
  36. Anyway we accept cap where locksmiths are concerned, this has not to be the situation. locksmith Sterling Heights

    ReplyDelete
  37. Then, at that point, you may not be given a statement for the locksmith administration or given a bogus statement. locksmith Madison heights

    ReplyDelete
  38. Today, most service providers allow call-in requests for a locksmith service, so that troubled individuals can easily seek expert help during dire situations. Navigate to the site

    ReplyDelete
  39. By releasing this video online about commercial window film installers. I thought this post to be quite interesting and valuable to our understanding. I appreciate you sharing this content with us.

    ReplyDelete
  40. If you're in a hurry, you may force the auto just like the wind. And consequently, regularly harm your automobile in a few manners or the other. This is probably viable and you spoil the window of your automobile to get again your keys in anxiousness.

    ReplyDelete
  41. A great place to find a locksmiths in Dubai, Sharjah, Ajman, Ras Al-Khaimah, Al Ain and Abu Dhabi. Dubai Locksmiths

    ReplyDelete
  42. http://www.originalmechanic.com/2013/11/how-replace-auto-door-glass-on-1997.html?sc=1681852894645#c4012861330969305739

    ReplyDelete